Service manual

Burlak AT vehicle

50 km / h

cruising speed
on solid ground

5 km / h

cruising
speed afloat

150 hp

engine
power

up to 2 t

loading capacity

700 mm

clearance when
vehicle is fully loaded

Specifications

Dimensions

Length 7,380 mm
Width 2,900 mm
Height 3,200 mm
Height of the cabin 1,850 mm
Wheel outside diameter 1,750 mm
Width of wheels 750 mm
Wheel inside diameter 32''
Wheel track 2,120 mm
Ground clearance 700–750 mm

Weight

Curb weight 4 t ± 100 kg
Weight when vehicle is fully loaded 7 t
Ground pressure when vehicle is fully loaded 0.12 kg/cm 2
Total displacement 8,800kg
Total wheel displacement 7,200kg

ENGINE

Cummins 2.8 ISF turbodiesel engine
Power — 150 hp
Torque — 360 Nm at 1,800 rpm
Capacity — 2,800 cm3
Starting preheater — 220 V, 5 kW and "Binar", 5kW

SPEED

Maximum speed up to 80 km/h
Cruising speed at 2,000 rpm 50 km/h
Minimum (1 reduced
by 1,000 rpm)
1.5 km/h
Speed afloat without water propeller, due to the wheels up to 3 km/h
Speed afloat with water propeller up to 6 km/h

Body

Layout with front engine, access from the passenger compartment
Skinning — aluminum sheet up to 2 mm

Loading capacity

On solid ground up to 2 t of load and 9 people
On weak ground and afloat 1 t of load and 5 people

Fuel

Fuel tank volume - 400 l
Additional fuel tanks
(mounted individually) - 320 l

Fuel consumption

on solid ground 26-30 l / 100 km
off-road from 4 to 6 l/h
at idle 0.6–0.8 l/h

Transmission

Gearbox — Manual, five-speed
Central transfer case — Two-stage, three-shaft
Transmission modes:
Advanced 1/1
Reduced 1/2

Undercarriage

Suspension — independent, double wishbone, spring,suspension travel 200 mm
Steering control — without direct connection, due to hydraulic cylinder
Brakes — hydraulic, two-circuit

CONFIGURATION

INTERIOR

EVA floor mats
Insulation with isolon 30mm thick and finishing with gray carpet which is synthetic felt
Passenger seats (expedition configuration - 15 seats, cargo configuration - 6 seats)
Berths (expedition configuration - 8 berths, cargo configuration - 4 berths)
Cooking table, kitchen hood with lights
Electrical sockets 220V and 12V
Audiosystem

OUTSIDE EQUIPMENT

COME-UP 9500 winch (retractable both forward and backward through the pulley block)
White LED spotlight 175W
Yellow LED fog lamp, 180W, 18 diodes 10W each
White LED rear lights of a lamp 2x 16-18W
Additional ladder to the roof and the interior
Emergency vehicle lightning for oversized vehicle
Roof rails for securing cargo
Halogen low and high beams

ADDITIONAL EQUIPMENT AND TOOLS

Extinguisher
Emergency vehicle lighting (requirements of the Traffic Code for oversized vehicle)
Tire repair kit for light repairs
Crow bar, lug wrench
Oils
Filters (fuel, air, oil)
Spare tire 1750х720-32, 1 pc.
Pulley block, clevises, strop
mechanical jack with a platform
JONNESWAY tool kit
Special wrench for tightening of hub bearings
Special wrench for tightening of cardan nuts
Device for wheel replacement by 1 person
Batteries BOSCH-S4 028, 95 A·h, 2 pcs.
Inverter 1.5 kW/220V
Positive locking of all wheels through the cross-axle differential
Tire pressure control system with the possibility to control each wheel separately
2 kW Planar autonomous heater
Wheel pumping from the passenger compartment

ADDITIONAL REPAIR KIT

Semi-axle of inter-wheel reduction gear 1 pc
Gears of wheel reduction gear 1 kit
Wheel reduction gear cover 1 pc
Bearings (5 types):
12309 2 pcs
7511 1 pc
7514 1 pc
208 1 pc
Hanging bearing 1 pc
Oil seals (6 types):
65х80х10 1 pc
137x160x14 (Ural) 2 pcs
42x68x16.4 (UAZ) 1 pc
50х72х10 1 pc
40х62х10 2 pcs
45х62х12 1 pc
Tie rod end (upper control arms / steering rods) 1 pc
Silent block 40x60x14 1 pc
Silent block 52х54х12 1 pc
40x62 spherical joint with oil seals and a silent block 1 pc
GAZ-53 crosspiece 1 pc
GAZelle crosspiece 1 pc
Cardan nuts and bolts 1 kit / 4 pcs

ADDITIONAL CONFIGURATION

Inter-wheel positive-locking of all axles

Equipment for buoyancy improvement (propeller, floats,
wheel rims)

Additional fuel tanks

Equipment of the body Interior like an off-road camper van
(kitchen, dinning place, sauna, shower unit, births, TV etc.)

Equipment on the individual order (drilling rig)

OPERATION MANUAL FOR BURLAK AT VEHICLE

TEST DRIVE
IN EKATERINBURG

A free ride will give you an opportunity to see the possibilities of the AT vehicle.

The five-kilometre route runs along a dirt road, swampy terrain, includes steep uphills and downhills.